ZHANG Nan,ZHANG Zhaofeng,LI Bin,et al.Comparation of Nutritional Components in Hericium erinaceus Prepared by Different Drying Method[J].Northern Horticulture,2021,(08):92-98.[doi:10.11937/bfyy.20202230]
不同干燥方式猴头菇营养成分比较
- Title:
- Comparation of Nutritional Components in Hericium erinaceus Prepared by Different Drying Method
- 文献标志码:
- A
- 摘要:
- 以猴头菇菌株TJH-03为试材，采用日晒干燥、真空冷冻干燥、55 ℃热风干燥、65 ℃热风干燥和75 ℃热风干燥5种方式对新鲜猴头菇进行干制，并对干燥后猴头菇营养标签中标示成分、氨基酸、矿物质元素、脂肪酸组成、多糖、总酚和部分维生素等含量进行比较,以期选出猴头菇最佳的干燥方式。结果表明：5种不同干燥方式下猴头菇营养成分变化显著，65 ℃热风干燥和真空冷冻干燥可较好保留猴头菇各种营养成分。65 ℃热风干燥猴头菇营养标签中标示成分、氨基酸、矿物质元素含量最为合理均衡，冷冻干燥猴头菇多糖、总酚和部分维生素含量最高，与真空冷冻干燥相比，65 ℃热风干燥猴头菇多糖、总酚、抗坏血酸和硫胺素含量下降，但仍保持在80%左右，它们含量分别为(431±011)(40578±627)(1730±058)g?(100g)-1和(076±002)g?(100g)-1，但真空冷冻干燥时间过长（42 h），是65 ℃热风干燥所用时间的263倍，过程能耗大，干燥成本高。综合考虑猴头菇的品质、干燥效率和成本，65 ℃热风干燥猴适宜在猴头菇干燥加工产业推广。
- Abstract:
- Hericium erinaceus stains TJH-03 was used as experimental material,five drying processes were used on the Hericium erinaceus,fresh samples were dried by solar drying (SD),vacuum freeze drying (VFD) and hot-air drying (HAD) at three different temperatures (55,65,75 ℃) and the contents of elements on nutritional labeling,amino acids,mineral elements,polysaccharide,total phenol and vitamins were determined and compared,in order to chose the best processes.The results showed that all the five drying methods could significantly change nutritional components of H.erinaceus,and HAD at 65 ℃ and VFD provide better retention of various nutrients.The nutritional components (elements on nutritional labeling,amino acids and mineral elements) in 65 ℃HAD-dried sample were better than other four drying methods,with the highest content and the best proportion.The highest contents of polysaccharide,total phenol and vitamins were found in VFD-dried sample.Compared with VFD,the contents of polysaccharide,total phenol,vitamin C and vitamin B1 in 65 ℃HAD-dried sample decreased,but remained at about 80%.Their contents were (431±011)(40578±627)(1730±058)g?(100g)-1 and (076±002)g?(100g)-1,respectively.However,the time of VFD was 42 hours,which was 263 times of that of HAD at 65 ℃,and the process cost of VFD was expensive.Taking into consideration of product quality,drying efficiency and cost,HAD at 65 ℃ is the suitable dehydration way for industrialization of H.erinaceus dry processing.
参考文献/References:
[1]黄越.猴头菇抗氧化活性成分的分离纯化及结构鉴定研究[D].广州:华南理工大学,2018.[2]COHEN N,COHEN J,ASATIANI M D,et al.Chemical composition and nutritional and medicinal value of fruit bodies and submerged cultured mycelia of culinary-medicinal higher Basidiomycetes mushrooms[J].International Journal of Medicinal Mushrooms,2014,16(3):273-29.[3]ZHANG N,TANG Z F,ZHANG J,et al.Comparative transcriptome analysis reveals the genetic basis underlying the biosynthesis of polysaccharides in Hericium erinaceus[J].Botanical Studies,2019,60(1):15.[4]FEENEY M J,MILLER A M,ROUPAS P.Mushrooms-biologically distinct and nutritionally unique:Exploring a ‘Third Food Kingdom’[J].Nutrition Today,2014,49(6):301-307.[5]张鹏,图力古尔,包海鹰.猴头菌属真菌化学成分及药理活性研究概述[J].菌物研究,2011,9(1):54-62.[6]卜庆状.真空冷冻干燥和热风干燥对猴头菇营养品质的影响[J].食品科技,2018,43(5):97-101.[7]张乐,王赵改,杨慧,等.不同干燥方法对板栗品质的影响[J].核农学报,2016,30(12):2363-2372.[8]夏亚男,侯丽娟,齐晓茹,等.食品干燥技术与设备研究进展[J].食品研究与开发,2016,37(4):203-208.[9]宋凯,徐仰丽,郭远明,等.真空冷冻干燥技术在食品加工应用中的关键问题[J].食品与机械,2013,29(6):232-235.[10]钱正明,李春红,李文庆,等.冬虫夏草蛋白图谱及干燥条件对超氧化物歧化酶活性影响[J].菌物学报,2016,35(4):424-432.[11]吴素蕊,朱立,马明,等.羊肚菌冷冻干燥加工技术研究[J].中国食用菌,2012,31(5):49-51.[12]徐冲,陈杰,陈丽媛,等.真空冷冻干燥技术在食用菌加工中的应用研究[J].微生物学杂志,2015,35(6):96-99.[13]韩兴鹏.干燥方式对猴头菇品质及抗氧化活性的影响[D].哈尔滨:东北农业大学,2018.[14]张楠,谢宇,唐小雪,等.不同形状猴头菇营养成分的比较分析[J].核农学报,2018,32(10):1992-2001.[15]ZHANG N,SONG Z,XIE Y H,et al.Identification and characterization of antifungal active substances of Streptomyces hygroscopicus BS-112[J].World Journal of Microbiology and Biotechnology,2013,29(8):1443-1452.[16]李成成,尤晓蒙,付珺,等.高效液相色谱测定饲料中色氨酸含量方法的研究[J].食品工业科技,2016,37(9):308-310,316.[17]中华人民共和国卫生部.GB 500986-2016食品安全国家标准食品中抗坏血酸的测定[S].北京:中国标准出版社,2016.[18]李文盛,朱庆庆,孙金才,等.不同干燥工艺对南美白对虾仁品质的影响[J].食品与生物技术学报,2016,35(5):543-548.[18]岳冬,刘娜,朱为民,等.樱桃番茄与普通番茄部分品质指标及氨基酸组成比较[J].食品科学,2015,36(4):92-96.[19]姜冬梅,胡姝敏,孙欣瑶,等.新型婴儿配方乳粉脂肪酸母乳化研究[J].中国乳品工业,2017(1):15-17.[21]邱珊莲,林宝妹,张少平,等.不同干燥方式对嘉宝果品质的影响[J].福建农业学报,2019,34(9):1100-1107.[22]蒋鹏飞,王赵改,史冠莹,等.不同干燥方式的苦瓜粉品质特性及香气成分比较不[J].现代食品科技,2020,36(3):234-244.
相似文献/References:
[1]李凤美,周永斌,张志军,等.不同出菇方式对袋栽猴头菇的影响[J].北方园艺,2013,37(22):149.
LI Feng-mei,ZHOU Yong-bin,ZHANG Zhi-jun,et al.Effect of Different Fruiting Ways on Bag Cultured Hericium erinaceus Pers.[J].Northern Horticulture,2013,37(08):149.
[2]吴清山.猴头菇高效栽培关键技术[J].北方园艺,2014,38(18):161.
WU Qing-shan.Key Technologies of Efficient Cultivation of Hericium erinaceus[J].Northern Horticulture,2014,38(08):161.
[3]邓政东,程爱芳,郑廷金.猴头菇凝集素的提取工艺研究[J].北方园艺,2014,38(24):133.
DENG Zheng-dong,CHENG Ai-fang,ZHENG Ting-jin.Study on Extraction Technology of Lectin from Hericium erinaceus[J].Northern Horticulture,2014,38(08):133.
[4]倪淑君,王延锋,张海峰,等.寒地猴头菇菌种筛选试验[J].北方园艺,2015,39(02):127.[doi:10.11937/bfyy.201502036]
NI Shu-jun,WANG Yan-feng,ZHANG Hai-feng,et al.Screening Test of Hericium rinaceus Strains in Cold Regions[J].Northern Horticulture,2015,39(08):127.[doi:10.11937/bfyy.201502036]
[5]倪淑君,张海峰,王延锋,等.不同配方袋栽猴头菇试验[J].北方园艺,2015,39(11):138.[doi:10.11937/bfyy.201511034]
NI Shu-jun,ZHANG Hai-feng,WANG Yan-feng,et al.Study on Different Formula Bag Cultivation on the Influence of Hericium[J].Northern Horticulture,2015,39(08):138.[doi:10.11937/bfyy.201511034]
[6]潘 漫,盛 园 园,汤 玉 亮,等.棉籽壳菠萝皮混合培养基栽培猴头菇试验初探[J].北方园艺,2010,34(17):0.[doi:10.11937/bfyy.201017083]
,,et al.Ｎ ｅ ｗ ｌ ｙ Ｔ ｅ ｓ ｔ ｏ ｎ Ｃ ｕ ｌ ｔ ｉ ｖ ａ ｔ ｉ ｎ ｇ Ｈ ｅ ｒ ｉ ｃ ｉ ｕ ｍ ｅ ｒ ｉ ｎ ａ ｃ ｅ ｕ ｓ ｗ ｉ ｔ ｈ ｔ ｈ ｅ Ｍ ｉ ｘ ｅ ｄＭ ｅ ｄ ｉ ｕ ｍ ｏ ｆ Ｃ ｏ ｔ ｔ ｏ ｎ Ｓ ｅ ｅ ｄ Ｈ ｕ ｌ ｌ ｓ ａ ｎ ｄ Ｐ ｉ ｎ ｅ ａ ｐ ｐ ｌ ｅ Ｐ ｅ ｅ ｌ[J].Northern Horticulture,2010,34(08):0.[doi:10.11937/bfyy.201017083]
[7]杜颜宇,雷雨霞,潘尚丽,等.甘蔗渣不同配方栽培猴头菇试验[J].北方园艺,2015,39(23):150.[doi:10.11937/bfyy.201523042]
DU Yanyu,LEI Yuxia,PAN Shangli,et al.Study on Different Bagasse Formulas on Cultivation of Hericium erinacius[J].Northern Horticulture,2015,39(08):150.[doi:10.11937/bfyy.201523042]
[8]张江宁,杨春,丁卫英.不同干燥方式对红枣品质的影响[J].北方园艺,2016,40(14):139.[doi:10.11937/bfyy.201614035]
ZHANG Jiangning,YANG Chun,DING Weiying.Effect of Different Drying Methods on the Quality Properties of Jujube[J].Northern Horticulture,2016,40(08):139.[doi:10.11937/bfyy.201614035]
[9]王 玉,李 政,班 立 桐,等.猴头菇液体菌种培养基配方的研究[J].北方园艺,2011,35(09):0.[doi:10.11937/bfyy.201109074]
W ANG Yu,LI Zheng,BAN Li -tong,et al.Optimization of Fermentation Medium for Improving Mycelium of Hericiumerinaceus ( Bull. ) Per .[J].Northern Horticulture,2011,35(08):0.[doi:10.11937/bfyy.201109074]
[10]郝 涤 非.猴 头 菇 含 氮 物 质 测 定[J].北方园艺,2011,35(23):0.[doi:10.11937/bfyy.2011023055]
Ｄ ｅ ｔ ｅ ｒ ｍ ｉ ｎ ａ ｔ ｉ ｏ ｎ ｏ ｆ Ｎ ｉ ｔ ｒ ｏ ｇ ｅ ｎ － ｃ ｏ ｎ ｔ ａ ｉ ｎ ｉ ｎ ｇ Ｓ ｕ ｂ ｓ ｔ ａ ｎ ｃ ｅ ｓ ｏ ｆ Ｈ ｅ ｒ ｉ ｃ ｉ ｕ ｍ[J].Northern Horticulture,2011,35(08):0.[doi:10.11937/bfyy.2011023055]
备注/Memo
第一作者简介：张楠（1980-），男，博士，教授，现主要从事微生物学与食用菌种植等研究工作。E-mail:zhangnan@njtc.edu.cn.基金项目：四川省教育厅科技成果转化重大培育资助项目（17CZ0018）；国家中药管理局全国中药资源普查资助项目（GZY-KJS-2018-004）。收稿日期：2020-06-01